
When handling lithium-ion batteries, safety precautions are a must:1. Always wear gloves and goggles when dealing with damaged or aged batteries to protect from hazardous leaks or chemical exposure.2. Inspect all batteries for visible damage before transporting lithium-ion batteries. Cracks, dents, or leaks should be treated as warning signs.3. Avoid exposing batteries to heat or fire. . [pdf]
International, national, and regional governments, as well as other authorities, have developed regulations for air, road, rail, and sea transportation of lithium batteries and the products that incorporate these batteries. The regulations govern conduct, actions, procedures, and arrangements.
While there is not a specific OSHA standard for lithium-ion batteries, many of the OSHA general industry standards may apply, as well as the General Duty Clause (Section 5(a)(1) of the Occupational Safety and Health Act of 1970). These include, but are not limited to the following standards:
This paper concludes that effective regulations should promote and maximize safe transportation of lithium batteries through environmental testing and the elimination of unsafe circumstances that enable lithium batteries to become a hazard in transport. 1. Introduction
UN Regulations: UN UN3480 Lithium Ion Batteries, UN3481 Lithium Ion Batteries contained in equipment, UN3090 Lithium Metal Batteries, and UN3091 Lithium Metal Batteries contained in equipment UNOLS RVSS, Chapter 9.4 (8th Ed.), March 2003 Woods Hole Oceanographic Institution, safety document SG-10 This document generates no records.
Chinese airlines’ transport regulations for low-production-run or prototype lithium batteries, lithium batteries being shipped for recycling or disposal, and damaged or defective lithium batteries are in accordance with those introduced in Section 3.2.
Lithium batteries are a common feature in our modern world, powering everything from mobile phones to vehicles. Given the potential safety and environmental risks posed by batteries, we’re regularly asked about the key requirements for safe transportation, storage and disposal.

During discharge, sulfur from the sulfuric acid combines with lead to form lead sulfate while hydrogen combines with oxygen released at the positive plate to form water. This is given the formula below: During ch. . As the battery charging nears completion, the charge current is usually higher than the current required to break the. . Though hydrogen and oxygen gases are not as dangerous to breathe as hydrogen sulfide and sulfur dioxide gas, they are nevertheless dangerous in high concentrations as they can cause a fire. In all cases, the us. [pdf]
Ignition sources within close proximity (i.e. 1 -2 meters) may still cause an explosion due to localised concentrations of hydrogen gas escaping the battery housing. Ensure employees are aware of the risks of hydrogen gas through training, Safe Work Method Statements (SWMS) and promote the use of PPE during charging of the batteries.
If, instead of being used to charge the battery, an ampere-hour of charge is used completely to produce gas, it will create 0.01474 cubic feet, or 0.418 liters, of hydrogen per cell at standard temperature and pressure.
Overcharging, or lead acid battery malfunctions can produce hydrogen. In fact, if you look, there is almost always at least a little H2 around in areas where lead batteries are being charged. Overcharging, especially if the battery is old, heavily corroded or damaged can produce H2S.
And yes, I charge my car batteries in a well ventilated area so Hydrogen gas build-up is not an issue. It's he corrosive Hydrogen Sulfide gas that concerns me. Yes it can produce Hydrogen-Sulfide, but usually only if overcharged (which may be your case). There is a write-up at the Battery University Website which talks about it:
Normally, insignificant quantities of gases are released by a battery during the first part of the charge, as most of the charging current is used in charging the battery. Only during the last stages of the charge does the process become inefficient, so that an increasing portion of the current is used up by the creation of heat and gases.
Overcharging, especially if the battery is old, heavily corroded or damaged can produce H2S. Deteriorated, old or damaged lead acid batteries should be removed from service, as damaged batteries are much more likely to be associated with production of H2S.

The (IEC) was established in in 1906 and co-ordinates development of standards for a wide range of electrical products. The IEC maintains two committees, TC21 established in 1933 for rechargeable batteries, and TC35 established in 1948 for primary batteries, to develop standards. The current designation system was adopted in 1992. Battery types are designated with a letter/number sequence indicating number of cells, cell che. [pdf]
Knowing how to read these names helps in selecting the right battery for your needs. Yuasa, a leading battery manufacturer, uses a specific structure for its battery names. For instance, the initial letter 'Y' denotes Yuasa. Understanding these codes can simplify the process of identifying the right battery.
Battery types are designated with a letter/number sequence indicating number of cells, cell chemistry, cell shape, dimensions, and special characteristics. Certain cell designations from earlier revisions of the standard have been retained. The first IEC standards for battery sizes were issued in 1957.
Certain sizes, given by one or two digit numbers, represent standard size codes from previous editions of the standard. Sizes given as 4 or more digits indicate the diameter of the battery and the overall height. The numbers in the code correlate with the battery dimensions.
The current designation system was adopted in 1992. Battery types are designated with a letter/number sequence indicating number of cells, cell chemistry, cell shape, dimensions, and special characteristics. Certain cell designations from earlier revisions of the standard have been retained.
The letters and numbers in the code indicate the number of cells, cell chemistry, shape, dimensions, the number of parallel paths in the assembled battery and any modifying letters deemed necessary. A multi-section battery (two or more voltages from the same package) will have a multi-section designation.
For instance, the initial letter 'Y' denotes Yuasa. Understanding these codes can simplify the process of identifying the right battery. If you just want to find the perfect battery for your vehicle, you can check out our Yuasa Battery Finder on the website —just click Battery Search.
We are deeply committed to excellence in all our endeavors.
Since we maintain control over our products, our customers can be assured of nothing but the best quality at all times.